The biomass fired boilers adopts suspension combustion technology, is suitable for fuel, wood grain, biomass fuel (peanut shell, cotton shell, crops such as cotton stalk branch), sawdust, small wood, wood, wood, etc. Biomass wood burning boilers pressure parts for water pipe structure, set up under the adiabatic chamber of a stove or furnace.
This series boiler products structure and performance characteristics: under adiabatic fixed bar grate at the bottom of the chamber. Lteral wall oven door open, can feed and grate surface cleaning ash, lower part of front wall have fuel feeding mouth. Biomass wood fired boilers upper back wall of the chamber of a stove or furnace decorated with secondary air, forming s-shaped flame, increase the flame length, guarantee fuel sufficient fuel.
The back wall of the boiler is equipped with two explosion door, prevent damage of the deflagration furnace wall. Biomass wood burning boilers operation, and the system runs stably, clean and no pollution, little noise. The even in a lot of people are not affecting the residents live in the downtown. The hotel use biomass fuel/wood particles as fuel, compared with fuel gas boiler, the operation cost is only a third of the fuel/gas boiler, greatly reduces the operating costs. Is an ideal energy-saving environmental protection products.
Our company the main characteristics of biomass fuel boiler is as follows: through the design of the secondary air in the chamber of a stove or furnace, disturbance of flue gas power condition, timely supplementary oxygen combustion volatile state, improve the thermal efficiency and reduce emissions. The reasonable design to ensure the protection of the arch and the back of the grate, and avoid to produce periodic micro detonation chamber of a stove or furnace. For waste containing moisture, increase the preheating section length, provide effective heat source heating or directly into high temperature hot flue gas.
For peak load, or the waste containing glue and so on easy to coking, decorate a lot in the chamber of a stove or furnace heating surface. For waste, bar, sheet, crumbs, powder a variety of state, design a variety of feed way and the single feed way for users to choose from.
Biomass wood burning boilers have higher furnace, increasing the water wall. Thus increasing the fuel needed for suspension combustion flame length. The setting of the front wall two nozzle, fuel injection flue gas in the furnace arch of convergence between before and after the throat, so have a blazing fire fire and guarantee of sawdust, wood powder burning in good condition. Before the fuel charging tempering prevention device. The upper chamber of a stove or furnace and the combustion chamber side is equipped with state explosion door, in case of damage to the wall. Welcome to contact Zozen Boilers!